User Tag List

Reply
 
Thread Tools Rate Thread Display Modes
Old 08-19-2021, 04:38 PM #1
clanofwolves's Avatar
clanofwolves clanofwolves is offline
Member
 
Join Date: Jun 2013
Location: Raleigh, NC
Posts: 76
clanofwolves is on a distinguished road
clanofwolves clanofwolves is offline
Member
clanofwolves's Avatar
 
Join Date: Jun 2013
Location: Raleigh, NC
Posts: 76
clanofwolves is on a distinguished road
Possible issues with rear live axle??

My daughter's 2000 2WD had some issues of shaking and when I checked the vehicle out I found the rear shoes (especially the passenger side) was down to the metal on the edges. I replaced the shoes and they seem to work fine. However, she stated yesterday that the vehicle had a shake at highway speeds that scared her. I checked out all of my work as well as had her have her tires rotated and balanced which was more than needed. The issue wasn't alleviated.

I just jacked up the rear and put her in neutral and spun the tires and checked the propeller shaft joints. The driver's side tire, when spun correlated to the drive shaft turning as expected. However, when I spun the passenger side tire, there was a 1/4 tire turn delay until the driveshaft spun, in both directions, then it spun the same, and then it had a delay again. I honestly have never seen this.

Any ideas?
__________________
"Family and God - that is what's important. Money, cars, those are things that come and go."
clanofwolves is offline   Reply With QuoteReply With Quote
Old 08-19-2021, 04:54 PM #2
phattyduck phattyduck is offline
Elite Member
 
Join Date: Mar 2016
Location: Pasadena, CA
Posts: 5,377
phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute
phattyduck phattyduck is offline
Elite Member
 
Join Date: Mar 2016
Location: Pasadena, CA
Posts: 5,377
phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute
Were you watching the other side tire at the same time to see if it was swapping between spinning the driveshaft and opposite tire?

Even then, the 2WD prop shaft (from trans to diff) is known to go bad on the 2WD's with age. Both the u-joints and the shaft itself can have problems. There is a rubber coupler between an inner and outer shaft that wears with time and causes vibrations at highway speed (50-70mph) that feels just like bad u-joints or an out of balance driveshaft. If the rubber section goes bad, the only solution is a complete new driveshaft.

Vibration/buzz normally means driveshaft.

Shaking/wobbling normally means tires or something that rotates at that speed (brakes, etc.).

-Charlie
__________________
'99 4Runner SR5 Auto - 4WD swapped
'89 Camry Alltrac LE 3S-GTE 5spd
'17 Chevy Volt Premier
'16 Honda Odyssey Elite
Previous: '88 Camry Alltrac LE 3S-GE BEAMS, 90 Camry 3S-GTE, 90 Camry DX, '03 WRX wagon, '08 Outback XT
phattyduck is offline   Reply With QuoteReply With Quote
Old 08-19-2021, 05:02 PM #3
Bad Luck Bad Luck is offline
Senior Member
 
Join Date: Feb 2019
Location: Hot Springs, AR
Posts: 4,410
Real Name: Patrick
Bad Luck has a reputation beyond repute Bad Luck has a reputation beyond repute Bad Luck has a reputation beyond repute Bad Luck has a reputation beyond repute Bad Luck has a reputation beyond repute Bad Luck has a reputation beyond repute Bad Luck has a reputation beyond repute Bad Luck has a reputation beyond repute Bad Luck has a reputation beyond repute Bad Luck has a reputation beyond repute Bad Luck has a reputation beyond repute
Bad Luck Bad Luck is offline
Senior Member
 
Join Date: Feb 2019
Location: Hot Springs, AR
Posts: 4,410
Real Name: Patrick
Bad Luck has a reputation beyond repute Bad Luck has a reputation beyond repute Bad Luck has a reputation beyond repute Bad Luck has a reputation beyond repute Bad Luck has a reputation beyond repute Bad Luck has a reputation beyond repute Bad Luck has a reputation beyond repute Bad Luck has a reputation beyond repute Bad Luck has a reputation beyond repute Bad Luck has a reputation beyond repute Bad Luck has a reputation beyond repute
Quote:
Originally Posted by clanofwolves View Post
My daughter's 2000 2WD had some issues of shaking and when I checked the vehicle out I found the rear shoes (especially the passenger side) was down to the metal on the edges. I replaced the shoes and they seem to work fine. However, she stated yesterday that the vehicle had a shake at highway speeds that scared her. I checked out all of my work as well as had her have her tires rotated and balanced which was more than needed. The issue wasn't alleviated.

I just jacked up the rear and put her in neutral and spun the tires and checked the propeller shaft joints. The driver's side tire, when spun correlated to the drive shaft turning as expected. However, when I spun the passenger side tire, there was a 1/4 tire turn delay until the driveshaft spun, in both directions, then it spun the same, and then it had a delay again. I honestly have never seen this.

Any ideas?
What you're feeling/seeing is backlash in the rear differential and it's normal operation. All vehicles have backlash but you will get more as components wear.

Can you describe your problem in more detail? Speed, accelerating/braking/coasting, turning, feel it in the your seat, steering wheel shaking?
__________________
2000 SR5 V6 Manual 4WD https://www.toyota-4runner.org/3rd-g...biography.html
2000 Limited V6 Auto E-Locker Sold 3/2022
Bad Luck is offline   Reply With QuoteReply With Quote
Old 08-21-2021, 10:40 AM #4
clanofwolves's Avatar
clanofwolves clanofwolves is offline
Member
 
Join Date: Jun 2013
Location: Raleigh, NC
Posts: 76
clanofwolves is on a distinguished road
clanofwolves clanofwolves is offline
Member
clanofwolves's Avatar
 
Join Date: Jun 2013
Location: Raleigh, NC
Posts: 76
clanofwolves is on a distinguished road
Thanks for your feedback.

So I went out and test drove it with your inquiries in mind:

County road test:
Slow acceleration to 50 mph nothing overtly noticeable.
However, when backing off the gas down a long hill, there was slight shaking in the steering wheel, shifter and seat as it slowed to 45. Acceleration back to 50 mph seemed to reduce the recent vibration.

Highway test:
Moderate acceleration to 80 mph, again, nothing overtly noticeable.
When backing off the gas there as a noticeable shake in the steering and seat. When I performed this again (accelerate to 80 or so cruising speed and then reduced acceleration), it seems the seat area vibration is most pronounced, almost creating a noise or hum along with the feeling of the vibration.
__________________
"Family and God - that is what's important. Money, cars, those are things that come and go."
clanofwolves is offline   Reply With QuoteReply With Quote
Old 08-21-2021, 10:43 AM #5
clanofwolves's Avatar
clanofwolves clanofwolves is offline
Member
 
Join Date: Jun 2013
Location: Raleigh, NC
Posts: 76
clanofwolves is on a distinguished road
clanofwolves clanofwolves is offline
Member
clanofwolves's Avatar
 
Join Date: Jun 2013
Location: Raleigh, NC
Posts: 76
clanofwolves is on a distinguished road
Quote:
Originally Posted by phattyduck View Post
Were you watching the other side tire at the same time to see if it was swapping between spinning the driveshaft and opposite tire?

Even then, the 2WD prop shaft (from trans to diff) is known to go bad on the 2WD's with age. Both the u-joints and the shaft itself can have problems. There is a rubber coupler between an inner and outer shaft that wears with time and causes vibrations at highway speed (50-70mph) that feels just like bad u-joints or an out of balance driveshaft. If the rubber section goes bad, the only solution is a complete new driveshaft.

Vibration/buzz normally means driveshaft.

Shaking/wobbling normally means tires or something that rotates at that speed (brakes, etc.).

-Charlie
Thanks for your reply Charlie. My daughter had the tires rotated and balanced, and the alignment seems to be true in road tests, but I could have that checked as well.

It seems that there is a shake/vibration that comes when the truck is decelerating, not under acceleration. (see reply above as I tested this on a County as well as an Interstate road with the same observations.
__________________
"Family and God - that is what's important. Money, cars, those are things that come and go."
clanofwolves is offline   Reply With QuoteReply With Quote
Old 08-21-2021, 01:30 PM #6
clanofwolves's Avatar
clanofwolves clanofwolves is offline
Member
 
Join Date: Jun 2013
Location: Raleigh, NC
Posts: 76
clanofwolves is on a distinguished road
clanofwolves clanofwolves is offline
Member
clanofwolves's Avatar
 
Join Date: Jun 2013
Location: Raleigh, NC
Posts: 76
clanofwolves is on a distinguished road
Also, I just replaced the rotors as my daughter stated that "everyone is telling me it has to be the rotors," even though I disagreed. Well, she bought them, I did the labor, so there's that.

Test drove it and nothing changed for the better.
__________________
"Family and God - that is what's important. Money, cars, those are things that come and go."
clanofwolves is offline   Reply With QuoteReply With Quote
Old 08-22-2021, 10:43 PM #7
D'arce D'arce is offline
Member
 
Join Date: Oct 2018
Location: Williamsburg, VA
Posts: 181
D'arce will become famous soon enough
D'arce D'arce is offline
Member
 
Join Date: Oct 2018
Location: Williamsburg, VA
Posts: 181
D'arce will become famous soon enough
So is the shaking from the front or the back? How many miles are on this beast? If I was going to check the ujoints, (with trans in neutral, wheels down) I would hold the yoke in one hand and the driveshaft in the other. Try and twist in opposite directions. Muscle them around and look for play. Check the yoke at the 3rd member and the output shaft at the transmission. Does it have a double joint at the trans? As others have mentioned there is also a splined joint in the shaft itself. You can try and push pull and look for deviation...

I can't see feeling this in the steering wheel though.
__________________
1996 4Runner with a 3rz-fe, e-locker and 5spd
2005 Passat TDI 5spd swapped
1997 E350 4x4 7.3 Powerstroke

Last edited by D'arce; 08-22-2021 at 10:45 PM.
D'arce is offline   Reply With QuoteReply With Quote
Old 08-23-2021, 02:01 PM #8
phattyduck phattyduck is offline
Elite Member
 
Join Date: Mar 2016
Location: Pasadena, CA
Posts: 5,377
phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute
phattyduck phattyduck is offline
Elite Member
 
Join Date: Mar 2016
Location: Pasadena, CA
Posts: 5,377
phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute
Quote:
Originally Posted by D'arce View Post
Does it have a double joint at the trans? As others have mentioned there is also a splined joint in the shaft itself. You can try and push pull and look for deviation...
The 2WD shaft does not have a splined section at the center, it uses a slip yoke at the trans with single joints at each end.

It does seem like the next step is manually checking the driveshaft. 4 nuts/bolts at the rear diff and it will slide out. Check for good operation of the u-joints.

Since it doesn't happen at steady-state cruise, it is less likely to be an issue with the main part of the shaft, but it could still be u-joints.

-Charlie
__________________
'99 4Runner SR5 Auto - 4WD swapped
'89 Camry Alltrac LE 3S-GTE 5spd
'17 Chevy Volt Premier
'16 Honda Odyssey Elite
Previous: '88 Camry Alltrac LE 3S-GE BEAMS, 90 Camry 3S-GTE, 90 Camry DX, '03 WRX wagon, '08 Outback XT
phattyduck is offline   Reply With QuoteReply With Quote
Old 08-24-2021, 07:33 PM #9
clanofwolves's Avatar
clanofwolves clanofwolves is offline
Member
 
Join Date: Jun 2013
Location: Raleigh, NC
Posts: 76
clanofwolves is on a distinguished road
clanofwolves clanofwolves is offline
Member
clanofwolves's Avatar
 
Join Date: Jun 2013
Location: Raleigh, NC
Posts: 76
clanofwolves is on a distinguished road
Quote:
Originally Posted by D'arce View Post
So is the shaking from the front or the back? How many miles are on this beast? If I was going to check the ujoints, (with trans in neutral, wheels down) I would hold the yoke in one hand and the driveshaft in the other. Try and twist in opposite directions. Muscle them around and look for play. Check the yoke at the 3rd member and the output shaft at the transmission. Does it have a double joint at the trans? As others have mentioned there is also a splined joint in the shaft itself. You can try and push pull and look for deviation...

I can't see feeling this in the steering wheel though.
Can't tell, but the shaking definitely isn't simply the front, that's for sure. The beast has just under 300K.

There is NO play in the u-joints that I can muster out of them at all.
__________________
"Family and God - that is what's important. Money, cars, those are things that come and go."
clanofwolves is offline   Reply With QuoteReply With Quote
Old 08-24-2021, 07:34 PM #10
phattyduck phattyduck is offline
Elite Member
 
Join Date: Mar 2016
Location: Pasadena, CA
Posts: 5,377
phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute
phattyduck phattyduck is offline
Elite Member
 
Join Date: Mar 2016
Location: Pasadena, CA
Posts: 5,377
phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute phattyduck has a reputation beyond repute
Quote:
Originally Posted by clanofwolves View Post
Can't tell, but the shaking definitely isn't simply the front, that's for sure. The beast has just under 300K.

There is NO play in the u-joints that I can muster out of them at all.
It may not be play, it may be tight spots instead. Pull it out of there and test manually.

-Charlie
__________________
'99 4Runner SR5 Auto - 4WD swapped
'89 Camry Alltrac LE 3S-GTE 5spd
'17 Chevy Volt Premier
'16 Honda Odyssey Elite
Previous: '88 Camry Alltrac LE 3S-GE BEAMS, 90 Camry 3S-GTE, 90 Camry DX, '03 WRX wagon, '08 Outback XT
phattyduck is offline   Reply With QuoteReply With Quote
Old 08-24-2021, 07:35 PM #11
clanofwolves's Avatar
clanofwolves clanofwolves is offline
Member
 
Join Date: Jun 2013
Location: Raleigh, NC
Posts: 76
clanofwolves is on a distinguished road
clanofwolves clanofwolves is offline
Member
clanofwolves's Avatar
 
Join Date: Jun 2013
Location: Raleigh, NC
Posts: 76
clanofwolves is on a distinguished road
Quote:
Originally Posted by phattyduck View Post
It does seem like the next step is manually checking the driveshaft. 4 nuts/bolts at the rear diff and it will slide out. Check for good operation of the u-joints.
-Charlie
So I need to pull the driveshaft to check it correct? I can do that in the AM.

Thanks!

Dave
__________________
"Family and God - that is what's important. Money, cars, those are things that come and go."
clanofwolves is offline   Reply With QuoteReply With Quote
Old 08-25-2021, 08:31 AM #12
clanofwolves's Avatar
clanofwolves clanofwolves is offline
Member
 
Join Date: Jun 2013
Location: Raleigh, NC
Posts: 76
clanofwolves is on a distinguished road
clanofwolves clanofwolves is offline
Member
clanofwolves's Avatar
 
Join Date: Jun 2013
Location: Raleigh, NC
Posts: 76
clanofwolves is on a distinguished road
Quote:
Originally Posted by phattyduck View Post
It may not be play, it may be tight spots instead. Pull it out of there and test manually.

-Charlie
Will do, thanks!!
__________________
"Family and God - that is what's important. Money, cars, those are things that come and go."
clanofwolves is offline   Reply With QuoteReply With Quote
Old 08-25-2021, 02:39 PM #13
clanofwolves's Avatar
clanofwolves clanofwolves is offline
Member
 
Join Date: Jun 2013
Location: Raleigh, NC
Posts: 76
clanofwolves is on a distinguished road
clanofwolves clanofwolves is offline
Member
clanofwolves's Avatar
 
Join Date: Jun 2013
Location: Raleigh, NC
Posts: 76
clanofwolves is on a distinguished road
Quote:
Originally Posted by phattyduck View Post
It may not be play, it may be tight spots instead. Pull it out of there and test manually.

-Charlie
I pulled it and the rear U-Joint is free in one joint, but stiff in another joint especially when bent one way over the other.



Seem like the culprit? Now to figure how to replace it....
__________________
"Family and God - that is what's important. Money, cars, those are things that come and go."
clanofwolves is offline   Reply With QuoteReply With Quote
Old 08-25-2021, 02:42 PM #14
cl4Rk's Avatar
cl4Rk cl4Rk is offline
Member
 
Join Date: Dec 2020
Location: KC
Posts: 823
cl4Rk is a splendid one to behold cl4Rk is a splendid one to behold cl4Rk is a splendid one to behold cl4Rk is a splendid one to behold cl4Rk is a splendid one to behold cl4Rk is a splendid one to behold
cl4Rk cl4Rk is offline
Member
cl4Rk's Avatar
 
Join Date: Dec 2020
Location: KC
Posts: 823
cl4Rk is a splendid one to behold cl4Rk is a splendid one to behold cl4Rk is a splendid one to behold cl4Rk is a splendid one to behold cl4Rk is a splendid one to behold cl4Rk is a splendid one to behold
Quote:
Originally Posted by clanofwolves View Post
I pulled it and the rear U-Joint is free in one joint, but stiff in another joint especially when bent one way over the other.
Seem like the culprit? Now to figure how to replace it....
Is there any use in cleaning that up really well and then pumping the zerk fittings full of new grease to see if you can bring it back to life? (I don't know the answer.)
__________________
2000 SR-5 V6 4x4 Auto
"Ol' Ruby" - build thread
@Y2K_4X4

Last edited by cl4Rk; 08-25-2021 at 03:13 PM.
cl4Rk is offline   Reply With QuoteReply With Quote
Old 08-26-2021, 07:44 AM #15
clanofwolves's Avatar
clanofwolves clanofwolves is offline
Member
 
Join Date: Jun 2013
Location: Raleigh, NC
Posts: 76
clanofwolves is on a distinguished road
clanofwolves clanofwolves is offline
Member
clanofwolves's Avatar
 
Join Date: Jun 2013
Location: Raleigh, NC
Posts: 76
clanofwolves is on a distinguished road
Quote:
Originally Posted by cl4Rk View Post
Is there any use in cleaning that up really well and then pumping the zerk fittings full of new grease to see if you can bring it back to life? (I don't know the answer.)
I don't know either, but a new MOOG joint is $19, so I went that way. The local machine shop pressed it out and installed the new one for $30, and I thought that quite a good deal as I'd have to use a hammer and some joint support blocks made of wood laying around and be on my knees in the heat more than likely...
__________________
"Family and God - that is what's important. Money, cars, those are things that come and go."
clanofwolves is offline   Reply With QuoteReply With Quote
Reply

Tags
checked , rear , side , spun , tire

Thread Tools
Display Modes Rate This Thread
Rate This Thread:

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is On

Forum Jump

Similar Threads
Thread Thread Starter Forum Replies Last Post
Rear Axle Seal: Axle Puller Tool Design nobb 3rd gen T4Rs 29 11-23-2019 07:39 AM
WTB: Philadelphia- Non rusty 3rd gen rear axle of rear axle cover 4:10 Temple90 Want to Buy/Trade 0 05-14-2019 12:34 PM
Rear Axle Issues purevenom1 Classic T4Rs 8 03-09-2011 11:09 PM

Powered by vBadvanced CMPS v3.2.2

All times are GMT -4. The time now is 12:50 PM.

Powered by vBulletin® Version 3.8.11
Copyright ©2000 - 2024, vBulletin Solutions Inc.
Search Engine Optimisation provided by DragonByte SEO (Pro) - vBulletin Mods & Addons Copyright © 2024 DragonByte Technologies Ltd.
Feedback Buttons provided by Advanced Post Thanks / Like (Lite) - vBulletin Mods & Addons Copyright © 2024 DragonByte Technologies Ltd.
User Alert System provided by Advanced User Tagging (Lite) - vBulletin Mods & Addons Copyright © 2024 DragonByte Technologies Ltd.
***This site is an unofficial Toyota site, and is not officially endorsed, supported, authorized by or affiliated with Toyota. All company, product, or service names references in this web site are used for identification purposes only and may be trademarks of their respective owners. The Toyota name, marks, designs and logos, as well as Toyota model names, are registered trademarks of Toyota Motor Corporation***Ad Management plugin by RedTyger
 
Copyright © 2020