I've been doing research on this all day today and I've come up empty handed. My issue is that when my sunroof is in the closed position it sits about 1/4 inch below where it is supposed to. In order to cut down on wind noise, every time I drive the car I have to tap the open button for half a second in order to get it into the actual fully closed position.
I HAVE tried reinitializing it, several times, with no luck.
I found
this thread where user Pennywise is having the same issue, and resolves it using the
TSB BO016-16 (Moonroof Stuck/Improper Operation). I followed the TSB, removed the map light assembly, the two side garnishes, the torx screws and the glass.
At this point I noticed that my sunroof and assembly looks vastly different than the way it is shown in the TSB. For one, my roof had 3 Torx screws on either side instead of 2 shown in the TSB.
The centering marks pictured are also nowhere to be found, I think I found them, but it's nowhere near what's pictured in the TSB.
It also seems my sunroof motor is nowhere to be found. I searched all over inside where the map light assembly goes for the gear assembly and motor but it is not there. This is the crucial step i'm at, I have to get it out in order to adjust the rails.
Here's mine compared to the picture in the TSB...
And from the reverse angle...
I found the tag for the sunroof (It's a Webasto Hollandia 700) so I figured that I might be able to find a service manual for the sunroof itself, but I had no luck.
I then remembered that I had a PDF copy of the 2006 4runner Repair Manual, so I found the section on the Sliding Roof Housing (06600210.pdf) and referenced the location of the motor compared to the location of the wind deflector. I found that same location on my truck and it seems like it should be exactly where the TSB describes it (right above the control switches).
I then found
this thread mentioning referencing the Haynes manual, so I went out and bought the hanes manual. Unfortunately there is not a sunroof/moonroof section anywhere in there. I flipped through it page by page.
So... my question to you is: where is the sunroof motor so I can remove it and adjust my sunroof tracks? Did I miss something?