Hi guys.
thanks for all the input. I don't know if there was a lot of noise before it blew, I do know that my 19 year old daughter was driving it on 270 and I would guess was going 70 or higher)... it was fixed on the 31st of Jan and the engine blew on the 14th. Probably the second or third time it had been driven since we picked it up. You are right I should have gone to a Toyota shop for a major repair like that. I have used my saab guys for years (they used to only do SAABs). anyway, here are the emails on what was originally fixed and the email about what then broke again if they help. I was planning on asking them to refund the labor.....
==========
Sure, tomorrow afternoon will be fine. The only unanticipated item we replaced on the Toyota was the radiator...we had to remove it to access the main crankshaft bolt as part of the headgasket/timing belt job, and it was frozen in place, so we had to cut/break it out of the car and thus replace it. It appears to be the original but I am not certain of that. We also replaced the upper and lower radiator hoses preventively at that time.
The grand total with tax is $2864.23.
===============
Hi Theresa,
We believe we have identified the issue (exhaust cam timing) and we are attempting to correct it this afternoon. I will update again later today, hopefully with the news that it is ready to go.
====================
Well...we finished, but the truck does not run right and the check engine light is flashing at us. We don't know if it is something in the cam timing or an ignition issue, but we obviously need to identify and correct this issue before you can have it back. I am sorry for the additional delays but we will make it right.
======================
We are going back together with your truck, but we are waiting on a new tensioner for the timing belt. The kit I ordered did not come with a new tensioner. The local dealer is delivering one this afternoon, but it has not arrived yet. Assuming this part does arrive at some point this afternoon, we should be able to wrap it up tomorrow.
Thanks again for your patience.
======================
Hi Theresa,
Just wanted to update you on the truck...we didn't get to start working on it until this morning, but it is going well so far. He is not too far from pulling the heads off, should happen this afternoon. Barring any complications or need to send the head(s) off to the machine shop, I still think it could be done by tomorrow evening or Saturday morning.
We found the middle cylinder on the passenger side to be completely full of coolant!
=====================
and here was the email from when the piston threw a rod....
========================================
Hi Theresa,
I have been speaking with Jay about your 4Runner. What an unfortunate turn of events. I looked into the value of these vehicles and was quite surprised that even at 16 years old and 200,000+ miles, this truck seems to be worth a fair amount. Obviously you have put a lot of money into it between the headgasket job we just did and the transmission you did before that.
We concluded that we would be comfortable with offering to install an engine assembly with the parts (including the engine itself) at cost, plus book labor and tax. I looked into options and found a couple:
A used engine, with 100,000 miles and a 1 year/12,000 mile warranty, would be about $4,800 installed plus tax.
A remanufactured engine, which would include new headgaskets, and carries a 3 year/unlimited mileage warranty including no-fault first repair, would be about $6,500 installed plus tax.
We would certainly transfer your new timing belt, tensioner, water pump, and anything else we could from the old engine. We cannot transfer the headgaskets themselves to the used engine.
If we order either of these engines today, we would receive it early next week. The replacement itself would take several days most likely.
Please let me know how you'd like to proceed.