Lift installed. Netted 2” front & rear which is about what I was after.
Before (note, great day for install, huh?):
(265/70/17 Gen Grab AT2, full set of steel Shrock skids plus sliders, 3rd row)
Driver, F: 34 1/4", R: 35 3/4"
Pass, F: 34 1/4", R: 36 1/4"
Front: Stock springs, Bilstein 5100s set to 1.75”, plus 1/4" poly top plate spacers from Wheeler’s.
Rear: Stock springs & shocks (for now…), Daystar 1.5” spacers, plus Firestone air bags.
Alright, I apologize ahead of time for the photo bomb, but hopefully it helps somebody else along the way.
A few pointers I gleaned in the process:
TIP:
Not sure I’ve seen this mentioned before, but I just about overlooked it and really would have been second guessing myself were it not for the FSM linked for download elsewhere on this site. Installing the front, you need to be sure the lower part of the spring faces the REAR of the vehicle on BOTH SIDES. I probably would have installed the passenger side backwards were it not for the stock set-up causing me a little pause.
TIP:
I’ve seen several people post about fighting the LCA to get the coilover out, having to use some kind of leverage device to push it down, try to wrestle things around the sway bar & tie rod ends, et al. I did too on the first side and installing by myself, would have really appreciated an extra set of hands from a helper. On the second side, I happened to loosen both LCA adjusters beforehand and the whole arm dropped right out of the way, allowing the coilover assembly to be easily removed. Do yourself a huge favor and FULLY LOOSEN THE LCA BOLTS!!
TIP:
Save yourself a lot of headache down the road and pull the LCA bolts out now and COAT THEM WITH ANTI-SEIZE. Takes essentially no time at this point but will hopefully save you from seized bolts, sawzall, and torch later.
TIP:
I used TWO SETS OF SPRING COMPRESSORS to compress the coil. My pneumatic ratchet was not up to the task with only one set and you are not even supposed to use air tools on these things in the first place, so I wasn’t about to try my impact gun on them. Cannot imagine doing this by hand with just a ratchet!
Bilstein assembly with Wheeler’s poly spacers ready to go in:
For the back, since I was installing a coil spacer that installs over the top of the stock bump stop, I left one segment of the factory bump stop in place, more or less the same height as the spacer. I cut it with a hand saw, then smoothed it out with a flap disc on my angle grinder… DON’T DO THAT!!! The high heat developed slung a tar-like mess of sticky fragments all over my work area… the back yard, in this case, which our dog proceeded to step in and track all around the house over the next several days. Doh!! WD-40 worked well to clean up the tacky remnants/surface, but didn’t find anything to help in the backyard rocks short of hand picking out the yuck as best I could and covering with a new layer of rock.
TIP:
Seems Toyota is using a couple different isolator/bump stop sizes for our 5th gens. Be sure to CHECK BEFORE ORDERING! Short of pulling it out altogether, I found I was able to tell it was 5.0” and not 4.6” by jacking up the rear end and eye balling it close enough using a set of calipers. I needed the 5.0” model, KT09100BK. Props to Wayne @ Daystar for fielding all my email questions along the way, too.
Rear installed: